[Federal Register Volume 76, Number 105 (Wednesday, June 1, 2011)]
[Rules and Regulations]
[Pages 31454-31456]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2011-13434]
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 25
[Docket No. NM445; Special Conditions No. 25-429-SC]
Special Conditions: Gulfstream Model GVI Airplane; Automatic
Speed Protection for Design Dive Speed
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Final special conditions.
-----------------------------------------------------------------------
SUMMARY: These special conditions are issued for the Gulfstream GVI
airplane. This airplane will have novel or unusual design features when
compared to the state of technology envisioned in the airworthiness
standards for transport category airplanes. These design features
include a high speed protection system. These special conditions
contain the additional safety standards that the Administrator
considers necessary to establish a level of safety equivalent to that
established by the existing airworthiness standards.
DATES: Effective Date: July 1, 2011.
FOR FURTHER INFORMATION CONTACT: Carl Niedermeyer, FAA, Airframe/Cabin
Safety Branch, ANM-115, Transport Standards Staff, Transport Airplane
Directorate, Aircraft Certification Service, 1601 Lind Avenue, SW.,
Renton, Washington 98057-3356; telephone (425) 227-2279; electronic
mail [email protected].
SUPPLEMENTARY INFORMATION:
Background
On March 29, 2005, Gulfstream Aerospace Corporation (hereafter
referred to as ``Gulfstream'') applied for an FAA type certificate for
its new Gulfstream Model GVI passenger airplane. Gulfstream later
applied for, and was granted, an extension of time for the type
certificate, which changed the effective application date to September
28, 2006. The Gulfstream Model GVI airplane will be an all-new, two-
engine jet transport airplane. The maximum takeoff weight will be
99,600 pounds, with a maximum passenger count of 19 passengers.
Type Certification Basis
Under provisions of Title 14, Code of Federal Regulations (14 CFR)
21.17, Gulfstream must show that the Gulfstream Model GVI airplane
(hereafter referred to as ``the GVI'') meets the applicable provisions
of 14 CFR part 25, as amended by Amendments 25-1 through 25-119, 25-
122, and 25-124. If the Administrator finds that the applicable
airworthiness regulations (i.e., 14 CFR part 25) do not contain
adequate or appropriate safety standards for the GVI because of a novel
or unusual design feature, special conditions are prescribed under the
provisions of Sec. 21.16.
Special conditions are initially applicable to the model for which
they are issued. Should the type certificate for that model be amended
later to include any other model that incorporates the same novel or
unusual design features, the special conditions
[[Page 31455]]
would also apply to the other model under provisions of Sec. 21.101.
In addition to complying with the applicable airworthiness
regulations and special conditions, the GVI must comply with the fuel
vent and exhaust emission requirements of 14 CFR part 34 and the noise
certification requirements of 14 CFR part 36. The FAA must also issue a
finding of regulatory adequacy pursuant to section 611 of Public Law
92-574, the ``Noise Control Act of 1972.''
The FAA issues special conditions, as defined in 14 CFR 11.19, in
accordance with Sec. 11.38, and they become part of the type
certification basis under Sec. 21.17(a)(2).
Novel or Unusual Design Features
The Gulfstream Model GVI airplane is equipped with a high speed
protection system that limits nose down pilot authority at speeds above
VC/MC, and prevents the airplane from actually
performing the maneuver required under Sec. 25.335(b)(1). The
applicable airworthiness regulations do not contain adequate or
appropriate safety standards for this design feature. These special
conditions are identical or nearly identical to those previously
required for type certification of other airplane models.
Discussion
Gulfstream proposes to reduce the speed margin between
VC and VD required by Sec. 25.335(b), based on
the incorporation of a high speed protection system in the GVI flight
control laws. The GVI is equipped with a high speed protection system
that limits nose down pilot authority at speeds above VC/
MC and prevents the airplane from actually performing the
maneuver required under Sec. 25.335(b)(1).
Section 25.335(b)(1) is an analytical envelope condition which was
originally adopted in Part 4b of the Civil Air Regulations to provide
an acceptable speed margin between design cruise speed and design dive
speed. Freedom from flutter and the airframe design loads are affected
by the design dive speed. While the initial condition for the upset
specified in the rule is 1g level flight, protection is afforded for
other inadvertent overspeed conditions as well. Section 25.335(b)(1) is
intended as a conservative enveloping condition for all potential
overspeed conditions, including non-symmetric ones.
To establish that all potential overspeed conditions are enveloped,
the applicant would demonstrate that the dive speed will not be
exceeded during pilot-induced or gust-induced upsets in non-symmetric
attitudes.
In addition, the high speed protection system in the GVI must have
a high level of reliability.
Discussion of Comments
Notice of proposed special conditions No. 25-11-04-SC for
Gulfstream GVI airplanes was published in the Federal Register on
February 16, 2011 (76 FR 8917). One supportive comment was received.
On March 29, 2011, Advisory Circular (AC) 25-7B, Flight Test Guide
for Certification of Transport Category Airplanes, was issued. This
revision supersedes the reference to AC 25-7A, Change 1, in special
condition 2 of the proposed special conditions. Therefore, the
reference to AC 25-7A, Change 1, section 32, paragraphs c.(3)(i) and
(iii) has been updated to AC 25-7B, section 32, paragraph c.3(a) and
(c), and the title of the AC has been included. Except for the updated
AC reference in special condition 2, these special conditions are
adopted as proposed.
Applicability
As discussed above, these special conditions are applicable to the
Gulfstream Model GVI airplane. Should Gulfstream apply at a later date
for a change to the type certificate to include another model
incorporating the same novel or unusual design features, these special
conditions would apply to that model as well.
Conclusion
This action affects only certain novel or unusual design features
of the GVI. It is not a rule of general applicability.
List of Subjects in 14 CFR Part 25
Aircraft, Aviation safety, Reporting and recordkeeping
requirements.
The authority citation for these special conditions is as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701, 44702, 44704.
The Special Conditions
Accordingly, pursuant to the authority delegated to me by the
Administrator, the following special conditions are issued as part of
the type certification basis for Gulfstream GVI airplanes.
1. In lieu of compliance with Sec. 25.335(b)(1), if the flight
control system includes functions that act automatically to initiate
recovery before the end of the 20 second period specified in Sec.
25.335(b)(1), VD/MD must be determined from the
greater of the speeds resulting from conditions (a) and (b) below. The
speed increase occurring in these maneuvers may be calculated if
reliable or conservative aerodynamic data are used.
(a) From an initial condition of stabilized flight at
VC/MC, the airplane is upset so as to take up a
new flight path 7.5 degrees below the initial path. Control
application, up to full authority, is made to try to maintain this new
flight path. Twenty seconds after initiating the upset, manual recovery
is made at a load factor of 1.5 g (0.5 acceleration increment), or a
greater load factor that is automatically applied by the system with
the pilot's pitch control neutral. Power, as specified in Sec.
25.175(b)(1)(iv), is assumed until recovery is initiated, at which time
power reduction and the use of pilot controlled drag devices may be
used.
(b) From a speed below VC/MC, with power to
maintain stabilized level flight at this speed, the airplane is upset
so as to accelerate through VC/MC at a flight
path 15 degrees below the initial path (or at the steepest nose down
attitude that the system will permit with full control authority if
less than 15 degrees). The pilot's controls may be in the neutral
position after reaching VC/MC and before recovery
is initiated. Recovery may be initiated three seconds after operation
of high speed warning system by application of a load factor of 1.5g
(0.5 acceleration increment), or such greater load factor that is
automatically applied by the system with the pilot's pitch control
neutral. Power may be reduced simultaneously. All other means of
decelerating the airplane, the use of which are authorized up to the
highest speed reached in the maneuver, may be used. The interval
between successive pilot actions must not be less than one second.
2. The applicant must also demonstrate that the speed margin,
established as above, will not be exceeded in inadvertent or gust
induced upsets resulting in initiation of the dive from non-symmetric
attitudes, unless the airplane is protected by the flight control laws
from getting into non-symmetric upset conditions. The upset maneuvers
described in AC 25-7B, Flight Test Guide for Certification of Transport
Category Airplanes, section 32, paragraphs c.3(a) and (c) may be used
to comply with this requirement.
3. Any failure of the high speed protection system that would
affect the speed margin determined by paragraphs 1. and 2. must be
improbable (occur at a rate less than 10-\5\ per flight
hour).
4. Failures of the system must be annunciated to the pilots, and
flight manual instructions must be provided to reduce the maximum
operating speeds, VMO/MMO. The operating speed
[[Page 31456]]
must be reduced to a value that maintains a speed margin between
VMO/MMO and VD/MD that is
consistent with showing compliance with Sec. 25.335(b) without the
benefit of the high speed protection system.
5. Master minimum equipment list (MMEL) relief for the high speed
protection system may be considered by the FAA Flight Operations
Evaluation Board (FOEB) provided that the flight manual instructions
indicate reduced maximum operating speeds as described in paragraph 4.,
and that no additional hazards are introduced with the high speed
protection system inoperative. In addition, the cockpit display of the
reduced operating speeds, as well as the overspeed warning for
exceeding those speeds, must be equivalent to that of the normal
airplane with the high speed protection system operative.
Issued in Renton, Washington, on May 24, 2011.
Ali Bahrami,
Manager, Transport Airplane Directorate, Aircraft Certification
Service.
[FR Doc. 2011-13434 Filed 5-31-11; 8:45 am]
BILLING CODE 4910-13-P