[Federal Register Volume 78, Number 112 (Tuesday, June 11, 2013)]
[Notices]
[Pages 35094-35098]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2013-13779]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

National Highway Traffic Safety Administration


Denial of Motor Vehicle Defect Petition, DP12-001

AGENCY: National Highway Traffic Safety Administration (NHTSA), DOT.

ACTION: Denial of petition for a defect investigation.

-----------------------------------------------------------------------

SUMMARY: This notice describes the reasons for denying a petition 
(DP12-001) submitted to NHTSA under 49 U.S.C. Subtitle B, Chapter V, 
Part 552, Subpart A, requesting that the agency ``open an 
investigation'' into ``the repeated final drive bearing failure and 
possibly flawed assembly controls of the final drive unit on BMW 
K1200LT [motorcycles].''

FOR FURTHER INFORMATION CONTACT: Bob Young, Office of Defects 
Investigation (ODI), NHTSA; 1200 New Jersey Ave. SE; Washington, DC 
20590. Telephone: 202-366-4806.

SUPPLEMENTARY INFORMATION: By letter dated November 28, 2011, Mr. 
Christopher D. Cimino wrote to NHTSA requesting that the agency open an 
investigation into ``the repeated final drive bearing failure and 
possibly flawed assembly controls of the final drive unit on BMW 
K1200LT [motorcycles]'' and to require BMW to ``recall the affected 
models for inspection of component wear and proper assembly of the 
[final drive].''
    NHTSA reviewed the material provided by the petitioner and other 
pertinent data that the agency gathered since first learning of this 
issue in February, 2003. The results of this review and NHTSA's 
analysis of the petition's merit is set forth in the DP12-001 Petition 
Analysis Report, published in its entirety as an appendix to this 
notice.
    For the reasons presented in the petition analysis report, it is 
unlikely that an order concerning the notification and remedy of a 
safety-related defect would be issued as a result of granting Mr. 
Cimino's request. Therefore, in view of the need to allocate and 
prioritize NHTSA's limited resources to best accomplish the agency's 
safety mission, the petition is denied.

    Authority: 49 U.S.C. 30162(d); delegations of authority at CFR 
1.50 and 501.8.

    Issued on: June 5, 2013.
Nancy Lummen Lewis,
Associate Administrator for Enforcement.

Appendix

Petition Analysis--DP12-001

1.0 Introduction

    On December 5, 2011 the National Highway Traffic Safety 
Administration (NHTSA) received a letter (dated November 28, 2011) 
from Mr. Christopher D. Cimino, requesting NHTSA to investigate 
repeated final drive bearing failure[s] on certain BMW K1200LT model 
motorcycles and require BMW to recall the affected models for 
inspection of component wear and proper assembly of the unit. In 
support of his request, Mr. Cimino cites: an earlier BMW motorcycle 
recall addressing a final drive oil loss issue (06V399); \1\ related 
consumer complaints filed with NHTSA; \2\ an internet-based registry 
of owners experiencing a final drive ``failure''; \3\ an article 
appearing in a motorcycle related magazine; \4\ and his own personal 
experience wherein he had to replace the final drive ring gear ball-
type bearing twice. Mr. Cimino also included the damaged bearing 
parts from his most recent incident. While Mr. Cimino did not style 
his letter as a petition in accordance with 49 U.S.C. Part 552.4, 
NHTSA is treating it as such.
---------------------------------------------------------------------------

    \1\ NHTSA Recall 06V399 was filed on 10-9-06. This recall 
addresses oil leaking from the speed sensor o-ring of approximately 
700 BMW motorcycles.
    \2\ Mr. Cimino cites 145 consumer complaints which he found at 
http://www-odi.nhtsa.dot.gov/complaints/.
    \3\ Now defunct, a internet-based registry of related final-
drive complaints could be found at www.bmwfinaldrive.com.
    \4\ Bill Shaw, ``Tarnished Roundel--Final Drive Failures Taint 
BMW's Image,'' Motorcycle Consumer News, Sep. 2008.
---------------------------------------------------------------------------

    In analyzing the petitioner's allegations and preparing a 
response, NHTSA:
     Reviewed and analyzed the petitioner's November 28th 
letter and attachments;
     Discussed Mr. Cimino's allegations with him;
     Reviewed NHTSA consumer complaints identified by Mr. 
Cimino and those submitted to the agency after he filed his request;
     Reviewed Early Warning Reporting (EWR) data submitted 
by BMW pursuant to C.F.R. Sec.  579.23;
     Reviewed information related to BMW's safety recall 
(06V399);
     Conducted a comprehensive internet-based search for 
information concerning sudden, unforeseen subject final drive 
bearing failure resulting in loss of motorcycle control;
     Reviewed NHTSA's consumer complaint database for 
relevant reports;
     Reviewed www.bmwlt.com, www.ibmwr.org, www.bmwmoa.org, 
and www.bmwra.org for relevant Internet forum postings;
     Analyzed data related to the internet-based registry of 
final drive-related complaints found at www.bmwfinaldrive.com;
     Conducted informal interviews with K1200LT owners at 
various BMW Motorcycle Owners of America (BMWMOA) and BMW Riders 
Association (BMWRA) national rallies;
     Participated in discussions with technical experts at 
the BMWMOA and BMWRA national rallies;
     Participated in discussions with BMW Motorrad (BMW's 
motorcycle division) dealer service personnel;
     Reviewed magazine articles pertaining to the final 
drive bearing issue, and conducted informal discussions with the 
authors of those articles;
     Conducted a comprehensive, internet-based search for 
information (including forum postings) concerning sudden, unforeseen 
subject final drive bearing failure resulting in loss of motorcycle 
control.
    The information gathered and reviewed during this comprehensive 
effort fails to establish that a safety-related defect trend 
involving a final drive bearing failure exists in the subject 
motorcycles. Consequently, the petition is denied.

2.0 The Petioner's Allegations

    The petitioner wrote to NHTSA on November 28, 2011 requesting 
that the agency open an investigation into ``the repeated final 
drive bearing failure and possibly flawed assembly controls of the 
final drive unit on BMW K1200LT [motorcycles].'' Prior to sending 
this letter, the petitioner experienced two crown gear bearing 
failures involving his model year (MY) 2001 K1200LT motorcycle. The 
first failure occurred in December, 2008 when the motorcycle had 
been driven 59,310 miles; the

[[Page 35095]]

second failure occurred on October 21, 2011 at 75,994 miles. Neither 
incident resulted in a loss of control. The petitioner, an 
experienced motorcyclist, free-lance journalist, and Motorcycle 
Safety Foundation ``Rider Coach,'' alleged that the defect exposes 
subject vehicle operators to ``potential loss of control, possible 
crash, injury and . . . eventual fatality.'' Regarding his own 
experience, the petitioner stated that when the final drive bearing 
failed, the bearing parts could have caused the rear wheel to lock 
at speed, likely resulting in a loss of control. Further, the final 
drive oil leaking from the damaged bearing seal onto to rear tire 
could have resulted in a loss of traction for the rear wheel.

3.0 Subject Motorcycles

    This analysis covers all MY 1998 through 2010 BMW K1200LT 
motorcycles (shown in Image (1) produced for sale in the United 
States. Weighing 866 lbs., this ``Luxury Tourer'' motorcycle is a 
direct competitor of the Honda ``Goldwing'' and was the heaviest 
motorcycle in BMW's lineup during those model years. As a ``full-
dress'' touring motorcycle, it was also equipped with large capacity 
panniers and an integrated tail trunk giving it a ``payload'' 
weight-carrying capability of 456 lbs. (including driver and 
passenger) for a gross vehicle weight rating of 1,322 lbs. All 
subject motorcycles are equipped with BMW's ``Paralever'' rear 
suspension/shaft drive system.
[GRAPHIC] [TIFF OMITTED] TN11JN13.000

4.0 Subject ``Final Drive''

    In 1988, BMW Motorrad introduced the ``Paralever'' rear 
suspension/shaft drive swingarm (an upgrade from the company's 
original ``Monolever'' single-sided swingarm first seen on the MY 
1980 R80GS). All of the subject motorcycles are manufactured with a 
``Paralever'' suspension/shaft drive (shown in Image 2). The ``final 
drive'' is this Paralever element:
[GRAPHIC] [TIFF OMITTED] TN11JN13.001

    Internally, the final drive is comprised of the components 
identified in Image 3. Owners report incidents of ``ball bearing'' 
(i.e., ``crown gear bearing'') and this analysis focuses on that 
allegation.

[[Page 35096]]

[GRAPHIC] [TIFF OMITTED] TN11JN13.002

5.0 Consumer Complaints

    In analyzing this petition's merit, NHTSA gathered information 
about allegations of final drive bearing failures. In particular, 
NHTSA looked for indications that the failure(s) were sudden, 
unforeseen, and resulted in the driver's inability to control the 
motorcycle.

5.1 ``BMW FinalDrive.com'' Database

    As owner concern about BMW final drive issues increased, an 
internet-based forum survey was conducted by a BMW motorcycle owner. 
By late 2009, at the survey's conclusion, 156 final drive bearing 
failure reports were logged with 70 involving the subject 
motorcycles. No verified crashes or loss of control allegations were 
noted.
    Bearings give different warnings when they are failing including 
noise, increased vibrations, and the visible loss of bearing 
material. The alleged final drive bearing failures listed in the BMW 
FinalDrive.com database are consistent with these universally 
accepted bearing failure characteristics. Under ``Precursor,'' those 
filing complaint(s) reported they became aware of impending bearing 
failure in the following ways:
     Vibration/Noise--64 reports
     Oil leak--27 reports
     Unknown--26 reports
     Ride Quality--16 reports
     Drain plug (debris noted on the magnet)--14 reports
     Static rear wheel looseness--8 reports
     No Warning--1 report

5.2 Internet Forums

    Numerous Internet forums concerning the alleged final drive 
bearing failures exist. Because the same person often posts about 
one event on multiple forums, obtaining an accurate count or 
verifying incidents is not practical. Nevertheless, NHTSA conducted 
a review of the forums and still failed to find any allegations of 
crown gear bearing failure that resulted in a loss of motorcycle 
control.

5.3 BMW Motorcycle Owners of America and BMW Riders Association Rallies

    Since 2003, when NHTSA became aware of final drive failures on 
the subject motorcycles, the agency has attended 10 national rallies 
catering exclusively to BMW motorcycle owners. Both the BMW 
Motorcycle Owners of America (MOA) and the BMW Riders Association 
(RA) hold annual rallies drawing thousands of BMW motorcycle riders 
including hundreds of BMW K1200LT riders. During the rallies 
attended by NHTSA, the staff informally interviewed BMW motorcycle 
owners (including those with K1200LTs) about any final drive issues 
they might have experienced. While many owners expressed concern 
about the perceived safety consequence of a final drive failure, 
those who actually experienced a crown gear bearing failure reported 
that they retained complete control of the motorcycle when the 
incident occurred.
    Additionally, while attending the rallies, NHTSA staff conducted 
seminars about the agency's safety defect program. During the 
question-and-answer portion of the seminars, NHTSA staff were asked 
about the agency's activities related to the BMW K1200LT final drive 
failure. As motorcyclists discussed their experience with a final 
drive bearing failure, NHTSA heard from many owners that a pre-ride 
check (as recommended by the Motorcycle Safety Foundation in its 
Basic Rider Course) would reveal if a bearing failure was imminent. 
If either rear wheel looseness and/or oil weeping from the ball 
bearing seal are noted, the bearing should be replaced before total 
failure occurs. Those who had experienced a final drive failure 
maintained that a loss of control could occur, but without 
exception, a loss of control was not reported.

5.4 BMW's Early Warning Reporting (EWR) Data

    Since 2003, vehicle manufacturers have been required to provide 
EWR data to NHTSA on a quarterly basis. This data includes reports 
of incidents involving death(s) or injury(ies) and field reports. A 
comprehensive search of the BMW EWR data failed to identify any 
reports involving a K1200LT final drive failure.

5.4 NHTSA's Consumer Complaint Database

    As of October 31, 2012, consumers have filed 122 reports with 
NHTSA involving BMW K1200LT motorcycles (with distinct vehicle 
identification numbers) alleging final drive failures. These reports 
were identified by searching NHTSA's database for all BMW complaints 
(cars and motorcycles) and manually reviewing them for relevance. In 
this way, NHTSA staff avoided searching too narrowly and identified 
all potential complaints. Complaints that either mentioned a final 
drive failure (even if the bearing wasn't identified) or described 
an event appearing consistent with a final drive failure were 
counted. In those instances where multiple failures were alleged, 
only the ``first'' failure was counted. Duplicative reports were not 
counted. Likewise NHTSA staff did not count those reports filed by 
K1200LT owners simply expressing a ``concern'' that their final 
drive might fail.
    The following tables represent the complaint data received by 
NHTSA sorted by report year, vehicle model year, and incident year. 
By report year, NHTSA found the following data in its database:

------------------------------------------------------------------------
                                                 Complaint
                  Report year                      count       Crashes
------------------------------------------------------------------------
2002..........................................           12            0
2003..........................................           27            0
2004..........................................           13            0
2005..........................................            9            0

[[Page 35097]]

 
2006..........................................           12            0
2007..........................................            8            0
2008..........................................            8            0
2009..........................................            8            0
2010..........................................            2            0
2011..........................................            2            0
2012..........................................           21            0
                                               -------------------------
    Total.....................................          122            0
------------------------------------------------------------------------

    By model year, NHTSA found the following data in its database:

------------------------------------------------------------------------
                                                 Complaint
                  Model year                       count       Crashes
------------------------------------------------------------------------
1999..........................................           39            0
2000..........................................           34            0
2001..........................................           16            0
2002..........................................           16            0
2003..........................................            9            0
2004..........................................            0            0
2005..........................................            4            0
2006..........................................            0            0
2007..........................................            1            0
2008..........................................            3            0
2009..........................................            0            0
2010..........................................            0            0
                                               -------------------------
    Total.....................................          122            0
------------------------------------------------------------------------

    By incident year, NHTSA found the following data in its 
database:

------------------------------------------------------------------------
                                                 Complaint
                 Incident year                     count       Crashes
------------------------------------------------------------------------
1999..........................................            1            0
2000..........................................            1            0
2001..........................................            6            0
2002..........................................           12            0
2003..........................................           22            0
2004..........................................           14            0
2005..........................................           10            0
2006..........................................           14            0
2007..........................................            6            0
2008..........................................            8            0
2009..........................................           10            0
2010..........................................            6            0
2011..........................................            6            0
2012..........................................            6            0
                                               -------------------------
    Total.....................................          122            0
------------------------------------------------------------------------

5.4.1 The Petitioner's Complaint

    On December 6, 2011, NHTSA received a letter (dated November 28, 
2011) from Mr. Christopher Cimino about his MY 2001 BMW K1200LT 
motorcycle. In this letter, Mr. Cimino alleges he experienced two 
failures of the final drive ring gear ball bearing on his 
motorcycle. Mr. Cimino states that the first failure occurred in 
December, 2008 at 59,310 miles and that he paid Engle Motors of 
Kansas City (a BMW dealer) approximately $400 to repair the 
motorcycle.\5\ Mr. Cimino further reports that his K1200LT sustained 
a second alleged final drive crown gear bearing failure on October 
21, 2011 at 75,994 miles. Mr. Cimino states that he had the 
motorcycle repaired the second time by Coast Riders Powersports in 
San Luis Obispo, CA (an independent motorcycle shop).
---------------------------------------------------------------------------

    \5\ Owners report a final drive repair or replacement cost 
averaging approximately $1,400.
---------------------------------------------------------------------------

    Through subsequent contact with Mr. Cimino, the agency learned 
that he had ridden his BMW K1200LT in multiple ``Iron Butt'' rallies 
(www.ironbutt.com) and on the Barber race track at a Reg Pridmore 
CLASS event (www.classrides.com).
    As with many K1200LT owners, Mr. Cimino claims that a crown gear 
bearing failure results in a condition that poses a risk to rider 
safety. Mr. Cimino also believes that if not for his ample riding 
experience, he would have lost control of his motorcycle and a crash 
would have occurred following the crown gear bearing failures he 
experienced on his motorcycle.

5.4.2 Calendar Year 2012 Complaints To NHTSA

    On February 3, 2012, a posting by Mr. Cimino appeared on a 
number of motorcycle-related internet forums.\6\ Within three hours, 
NHTSA received the first of 21 ``new'' complaints for BMW K1200LT 
final drive bearing failures. This count exceeded the number of 
final drive bearing failure complaints NHTSA had received in the 
previous 13 months.\7\
---------------------------------------------------------------------------

    \6\ For an example, see http://www.advrider.com/forums/showthread.php?t=761531.
    \7\ From January 1, 2011 to February 3, 2012, the agency 
received two relevant reports . . . one was from Mr. Cimino.
---------------------------------------------------------------------------

    Below is a listing of the 21 complaints NHTSA received following 
Mr. Cimino's internet forum posting:

[[Page 35098]]



----------------------------------------------------------------------------------------------------------------
                                                                         Failure
                Incident dte                  Recv'd dte    Model yr     mileage                Crash
----------------------------------------------------------------------------------------------------------------
6/21/11....................................       2/3/12         2003       143740  N
7/21/10....................................       2/3/12         2001        87000  N
3/14/11....................................       2/4/12         2002        58000  N
4/10/10....................................       2/4/12         2002        76244  N
12/6/08....................................       2/6/12         2003        30876  N
7/10/10....................................       2/8/12         2003        35116  N
5/18/10....................................       2/8/12         2000        38696  N
2/1/12.....................................      2/15/12         1999          Unk  N
2/2/06.....................................      2/21/12         1999          Unk  N
6/17/11....................................      2/24/12         1999        46000  N
2/25/12....................................       3/5/12         2008        42000  N
6/15/09....................................      3/13/12         2001        45151  N
7/15/11....................................       5/3/12         2005        23200  N
5/3/12.....................................       5/9/12         2000        87822  N
4/8/10.....................................       6/7/12         2002        57010  N
7/17/09....................................      6/29/12         1999        20500  N
5/1/09.....................................       7/5/12         2003        31555  N
8/24/12....................................      8/29/12         2000        37550  N
9/24/04....................................       9/6/12         1999        37290  N
5/15/12....................................     10/11/12         1999        42000  N
4/15/12....................................     10/22/12         2000        11500  N
----------------------------------------------------------------------------------------------------------------

6.0 NHTSA Analysis

    In assessing the petitioner's claim that a failure of the final 
drive crown gear ball bearing unreasonably subjects BMW K1200LT 
operators to a ``potential loss of [vehicle] control, possible 
crash, injury and, if left unaddressed, eventual fatality,'' the 
agency reviewed consumer complaints filed with NHTSA as well as 
those posted on internet forums.
    When NHTSA became aware of the alleged defect in 2003, the 
initial assessment was that, while final drive bearing failures 
posed a customer satisfaction issue for BMW, the crash risk was 
minimal. The subsequent nine years of subject motorcycle exposure 
without a crash reported appear to validate NHTSA's initial 
assessment. While the agency understands riders' concerns that a 
final drive bearing failure may result in a crash, NHTSA has not 
identified a single crash due to such a failure. NHTSA has found 
that when a bearing failure does occur on a K1200LT (even in those 
instances where the rider claims it was sudden and unforeseen), 
riders are able to bring their motorcycle to a safe stop.

7.0 Conclusion

    Based on the foregoing analysis, it is unlikely that NHTSA would 
issue an order to recall and remedy the alleged defect. In view of 
that conclusion, the petition by Mr. Cimino is denied.

[FR Doc. 2013-13779 Filed 6-10-13; 8:45 am]
BILLING CODE 4910-59-P