[Federal Register Volume 79, Number 17 (Monday, January 27, 2014)] [Notices] [Pages 4347-4348] From the Federal Register Online via the Government Publishing Office [www.gpo.gov] [FR Doc No: 2014-01462] ----------------------------------------------------------------------- DEPARTMENT OF HEALTH AND HUMAN SERVICES Food and Drug Administration [Docket No. FDA-2013-N-1427] Agency Information Collection Activities; Submission for Office of Management and Budget Review; Comment Request; Hazard Analysis and Critical Control Point Procedures for the Safe and Sanitary Processing and Importing of Juice AGENCY: Food and Drug Administration, HHS. ACTION: Notice. ----------------------------------------------------------------------- SUMMARY: The Food and Drug Administration (FDA) is announcing that a proposed collection of information has been submitted to the Office of Management and Budget (OMB) for review and clearance under the Paperwork Reduction Act of 1995. DATES: Fax written comments on the collection of information by February 26, 2014. ADDRESSES: To ensure that comments on the information collection are received, OMB recommends that written comments be faxed to the Office of Information and Regulatory Affairs, OMB, Attn: FDA Desk Officer, FAX: 202-395-7285, or emailed to [email protected]. All comments should be identified with the OMB control number 0910-0466. Also include the FDA docket number found in brackets in the heading of this document. FOR FURTHER INFORMATION CONTACT: FDA PRA Staff, Office of Operations, Food and Drug Administration, 1350 Piccard Dr., PI50-400B, Rockville, MD 20850, [email protected]. SUPPLEMENTARY INFORMATION: In compliance with 44 U.S.C. 3507, FDA has submitted the following proposed collection of information to OMB for review and clearance. Hazard Analysis and Critical Control Point (HACCP) Procedures for the Safe and Sanitary Processing and Importing of Juice--21 CFR Part 120 (OMB Control Number 0910-0466)--Extension FDA regulations in part 120 (21 CFR part 120) mandate the application of HACCP principles to the processing of fruit and vegetable juices. HACCP is a preventive system of hazard control designed to help ensure the safety of foods. The regulations were issued under FDA's statutory authority to regulate food safety under section 402(a)(4) of the Federal Food, Drug, and Cosmetic Act (the FD&C Act) (21 U.S.C. 342(a)(4)). Under section 402(a)(4) of the FD&C Act, a food is adulterated if it is prepared, packed, or held under insanitary conditions whereby it may have been contaminated with filth or rendered injurious to health. The Agency also has authority under section 361 of the Public Health Service Act (42 U.S.C. 264) to issue and enforce regulations to prevent the introduction, transmission, or spread of communicable diseases from one State, territory, or possession to another, or from outside the United States into this country. Under section 701(a) of the FD&C Act (21 U.S.C. 371(a)), FDA is authorized to issue regulations for the efficient enforcement of that act. The rationale in establishing an HACCP system of preventive controls is to design and check the process so that the final product is not contaminated--not test for contamination after it may have taken place. Under HACCP, [[Page 4348]] processors of fruit and vegetable juices establish and follow a preplanned sequence of operations and observations (the HACCP plan) designed to avoid or eliminate one or more specific food hazards, and thereby ensure that their products are safe, wholesome, and not adulterated; in compliance with section 402 of the FD&C Act. Information development and recordkeeping are essential parts of any HACCP system. The information collection requirements are narrowly tailored to focus on the development of appropriate controls and document those aspects of processing that are critical to food safety. In the Federal Register of November 20, 2013 (78 FR 69689), FDA published a 60-day notice requesting public comment on the proposed collection of information. No comments were received. FDA estimates the burden of this collection of information as follows: Table 1--Estimated Annual Recordkeeping Burden \1\ ---------------------------------------------------------------------------------------------------------------- Number of Average burden 21 CFR section Number of records per Total annual per Total hours recordkeepers recordkeeper records recordkeeping ---------------------------------------------------------------------------------------------------------------- 120.6(c) and 120.12(a)(1) and 1,875 365 684,375 0.1 (8 minutes). 68,438 (b); Require written monitoring and correction records for Sanitation Standard Operating Procedures (SSOPs). 120.7 and 120.12(a)(2), (b) 2,300 1.1 2,530 20.............. 50,600 and (c); Require written hazard analysis of food hazards. 120.8(b)(7) and 1,450 14,600 21,170,000 0.01 (1 minute). 211,700 120.12(a)(4)(i) and (b); Require a recordkeeping system that documents monitoring of the critical control points and other measurements as prescribed in the HACCP plan. 120.10(c) and 120.12(a)(4)(ii) 1,840 12 22,080 0.1 (8 minutes). 2,208 and (b); Require that all corrective actions taken in response to a deviation from a critical limit be documented. 120.11(a)(1)(iv) and (a)(2), 1,840 52 95,680 0.1 (8 minutes). 9,568 120.12(a)(5); Require records showing that process monitoring instruments are properly calibrated and that end-product or in-process testing is performed in accordance with written procedures. 120.11(b) and 120.12(a)(5) and 1,840 1 1,840 4............... 7,360 (b); Require that every processor record the validation that the HACCP plan is adequate to control food hazards that are likely to occur. 120.14(a)(2), (c), and (d); 308 1 308 4............... 1,232 Require that importers of fruit or vegetable juices, or their products used as ingredients in beverages, have written procedures to ensure that the food is processed in accordance with our regulations in part 120. 120.11(c) and 120.12(a)(5) and 1,840 1 1,840 4............... 7,360 (b); Require documentation of revalidation of the hazard analysis upon any changes that might affect the original hazard analysis (applies when a firm does not have an HACCP plan because the original hazard analysis did not reveal hazards likely to occur). --------------------------------------------------------------------------------- Total..................... .............. .............. .............. ................ 358,466 ---------------------------------------------------------------------------------------------------------------- \1\ There are no capital costs or operating and maintenance costs associated with this collection of information. Table 1 provides our estimate of the total annual recordkeeping burden of our regulations in part 120. We base our estimate of the average burden per recordkeeping on our experience with the application of HACCP principles in food processing. We base our estimate of the number of recordkeepers on our estimate of the total number of juice manufacturing plants affected by the regulations (plants identified in our official establishment inventory plus very small apple juice and very small orange juice manufacturers). These estimates assume that every processor will prepare sanitary standard operating procedures and an HACCP plan and maintain the associated monitoring records, and that every importer will require product safety specifications. In fact, there are likely to be some small number of juice processors that, based upon their hazard analysis, determine that they are not required to have an HACCP plan under these regulations. Dated: January 22, 2014. Leslie Kux, Assistant Commissioner for Policy. [FR Doc. 2014-01462 Filed 1-24-14; 8:45 am] BILLING CODE 4160-01-P