[Federal Register Volume 63, Number 129 (Tuesday, July 7, 1998)] [Proposed Rules] [Pages 36621-36622] From the Federal Register Online via the Government Publishing Office [www.gpo.gov] [FR Doc No: 98-17959] ----------------------------------------------------------------------- DEPARTMENT OF TRANSPORTATION Federal Aviation Administration 14 CFR Part 39 [Docket No. 98-NM-157-AD] RIN 2120-AA64 Airworthiness Directives; Dornier Model 328-100 Series Airplanes AGENCY: Federal Aviation Administration, DOT. ACTION: Notice of proposed rulemaking (NPRM). ----------------------------------------------------------------------- SUMMARY: This document proposes the adoption of a new airworthiness directive (AD) that is applicable to all Dornier Model 328-100 series airplanes. This proposal would require repetitive lubrication of the engine control push-pull cables. This proposal is prompted by issuance of mandatory continuing airworthiness information by a foreign civil airworthiness authority. The actions specified by the proposed AD are intended to prevent ice from building up on the engine control push- pull cables, which could result in friction or jamming of the engine controls, and consequent reduced controllability of the airplane. DATES: Comments must be received by August 6, 1998. ADDRESSES: Submit comments in triplicate to the Federal Aviation Administration (FAA), Transport Airplane Directorate, ANM-114, Attention: Rules Docket No. 98-NM-157-AD, 1601 Lind Avenue, SW., Renton, Washington 98055-4056. Comments may be inspected at this location between 9:00 a.m. and 3:00 p.m., Monday through Friday, except Federal holidays. The service information referenced in the proposed rule may be obtained from Fairchild Dornier, Dornier Luftfahrt GmbH, P.O. Box 1103, D-82230 Wessling, Germany. This information may be examined at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington. FOR FURTHER INFORMATION CONTACT: Norman B. Martenson, Manager, International Branch, ANM-116, FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 227-2110; fax (425) 227-1149. SUPPLEMENTARY INFORMATION: Comments Invited Interested persons are invited to participate in the making of the proposed rule by submitting such written data, views, or arguments as they may desire. Communications shall identify the Rules Docket number and be submitted in triplicate to the address specified above. All communications received on or before the closing date for comments, specified above, will be considered before taking action on the proposed rule. The proposals contained in this notice may be changed in light of the comments received. Comments are specifically invited on the overall regulatory, economic, environmental, and energy aspects of the proposed rule. All comments submitted will be available, both before and after the closing date for comments, in the Rules Docket for examination by interested persons. A report summarizing each FAA-public contact concerned with the substance of this proposal will be filed in the Rules Docket. Commenters wishing the FAA to acknowledge receipt of their comments submitted in response to this notice must submit a self-addressed, stamped postcard on which the following statement is made: ``Comments to Docket Number 98-NM-157-AD.'' The postcard will be date stamped and returned to the commenter. Availability of NPRMs Any person may obtain a copy of this NPRM by submitting a request to the FAA, Transport Airplane Directorate, ANM-114, Attention: Rules Docket No. 98-NM-157-AD, 1601 Lind Avenue, SW., Renton, Washington 98055-4056. Discussion The Luftfahrt-Bundesamt (LBA), which is the airworthiness authority for Germany, notified the FAA that an unsafe condition may exist on all Dornier Model 328-100 series airplanes. The LBA advises that it has received several reports of ice building up on the engine control push- pull cables during flight, which prompted operators to descend to a lower altitude (higher temperature) to melt off any build-up. Investigation revealed that the ice builds up on and around the conduit seal housing for the engine control push-pull cables. Such build-up of ice on the engine control push-pull cables, if not corrected, could result in friction or jamming of the engine controls, and consequent reduced controllability of the airplane. Explanation of Relevant Service Information Dornier has issued Alert Service Bulletins ASB-328-76-022, dated December 22, 1997, and ASB-328-76-015, Revision 3, dated January 9, 1998, which describe procedures for repetitive lubrication of the engine control push-pull cables at two locations along the cables. The LBA classified these alert service bulletins as mandatory and issued German airworthiness directives 1998-105, dated January 30, 1998, and 1997-148/3, dated February 26, 1998, in order to assure the continued airworthiness of these airplanes in Germany. FAA's Conclusions This airplane model is manufactured in Germany and is type certificated for operation in the United States under the provisions of Sec. 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and the applicable bilateral airworthiness agreement. Pursuant to this bilateral airworthiness agreement, [[Page 36622]] the LBA has kept the FAA informed of the situation described above. The FAA has examined the findings of the LBA, reviewed all available information, and determined that AD action is necessary for products of this type design that are certificated for operation in the United States. Explanation of Requirements of Proposed Rule Since an unsafe condition has been identified that is likely to exist or develop on other airplanes of the same type design registered in the United States, the proposed AD would require accomplishment of the actions specified in the alert service bulletins described previously. Interim Action This is considered to be interim action. The manufacturer has advised that it currently is developing a modification that will positively address the unsafe condition addressed by this AD. Once this modification is developed, approved, and available, the FAA may consider additional rulemaking. Cost Impact The FAA estimates that 50 airplanes of U.S. registry would be affected by this proposed AD, that it would take approximately 4 work hours per airplane to accomplish the proposed lubrication, and that the average labor rate is $60 per work hour. Based on these figures, the cost impact of the proposed AD on U.S. operators is estimated to be $12,000, or $240 per airplane. The cost impact figure discussed above is based on assumptions that no operator has yet accomplished any of the proposed requirements of this AD action, and that no operator would accomplish those actions in the future if this AD were not adopted. Regulatory Impact The regulations proposed herein would not have substantial direct effects on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, in accordance with Executive Order 12612, it is determined that this proposal would not have sufficient federalism implications to warrant the preparation of a Federalism Assessment. For the reasons discussed above, I certify that this proposed regulation (1) is not a ``significant regulatory action'' under Executive Order 12866; (2) is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) if promulgated, will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A copy of the draft regulatory evaluation prepared for this action is contained in the Rules Docket. A copy of it may be obtained by contacting the Rules Docket at the location provided under the caption ADDRESSES. List of Subjects in 14 CFR Part 39 Air transportation, Aircraft, Aviation safety, Safety. The Proposed Amendment Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration proposes to amend part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows: PART 39--AIRWORTHINESS DIRECTIVES 1. The authority citation for part 39 continues to read as follows: Authority: 49 U.S.C. 106(g), 40113, 44701. Sec. 39.13 [Amended] 2. Section 39.13 is amended by adding the following new airworthiness directive: Dornier Luftfahrt GmbH: Docket 98-NM-157-AD. Applicability: All Model 328-100 series airplanes, certificated in any category. Note 1: This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (b) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it. Compliance: Required as indicated, unless accomplished previously. To prevent ice from building up on the engine control push-pull cables, which could result in friction or jamming of the engine controls, and consequent reduced controllability of the airplane, accomplish the following: (a) Within 2 months after the effective date of this AD, lubricate the engine control push-pull cables in accordance with Dornier Alert Service Bulletins ASB-328-76-022, dated December 22, 1997, and ASB-328-76-015, Revision 3, dated January 9, 1998. Repeat the lubrication thereafter at intervals not to exceed 300 flight hours. (b) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, International Branch, ANM-116, FAA, Transport Airplane Directorate. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, International Branch, ANM-116. Note 2: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the International Branch, ANM-116. (c) Special flight permits may be issued in accordance with Secs. 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be accomplished. Note 3: The subject of this AD is addressed in German airworthiness directives 1998-105, dated January 30, 1998, and 1997- 148/3, dated February 26, 1998. Issued in Renton, Washington, on June 30, 1998. Stewart R. Miller, Acting Manager, Transport Airplane Directorate, Aircraft Certification Service. [FR Doc. 98-17959 Filed 7-6-98; 8:45 am] BILLING CODE 4910-13-P